ProTool Masonry Detergent 4 Gallon Case

New Masonry Cleaner   4 Gallon Case

Cleans masonry surfaces including  stone, brick, cracked block, pavers, hardy board and precast concrete.

Before starting.  Test a adjoining surfaces to understand protection needs, place a drop on the nearby surface (windows, dooors, frames, fixtures, allowing the drop to dwell for 15 minutes, if there is any discoloration these surfaces will need to be protected.

Recommended equipment:

Spray on with a down stream injector from a pressure washer, X-jet, a premixed solution from a tank based sprayer or you can use ProTool Clever injector spraying system for precision mixing.

 

Mix Ratio is 4 parts water to 1 part Masonry Cleaner (20% mix rate)

Coverage is 100 to 200 sqft of solution depending ion the porosity of the surface

Instruction:

1) Moisten the surface, wet it down but don't flood the surface

2) Apply the diluted solution, spray top down on vertical surfaces

3) Reapplication is often required where mortar has been splattered about.

4) After a dwell period scraping the larger splatter will speed up the process

Note: Reapplication is performed with rinsing in between

Watch for foaming as the foaming diminishes the work is completed.

5) When satisfied with the cleaning rinse the surface with water.

Know your surface, sandstone, limestone and other softer surfaces should be rinsed at a very low pressures. Garden Hose or about 60 psi

For more robust surfaces use a large sized orifice fan tip to rinse and generate a pressure below 800psi with a high flow on to rinse the more robust Brick and stone surfaces with your wand.

Compatible with

• Easy to setup and use
• Simple dosage mixture setting at various flow rates
• SH capable and supports a wide range of liquid or soluble concentrates
• Sprayer Pumps capable of 5 to 7 gpm continuous flow
• Adjustable and operates continuously
• 110v Power source for Pumps
• Softwash Mix Station: 150-0701

 

Safety Information

Use chemical resistant gloves 

Avoid prolonged contact with skin, do not wear contacts

do not combine the cleaner with aboy other chemical, only dilute with clear water.

Hazmat Reference UN3264